Characteristics of Cellulose Acetate Composite Membranes (Ca/Cs, Ca/Pva, Ca/Peg) As Cu(Ii) Metal Ion Filtration Membranes


Vina Amalia(1), Tety Sudiarti(2*), Rafa Mufidah(3), Yuliarti Yuliarti(4), Yusrina Nisrin(5), Yusuf Rohmatulloh(6)

(1) UIN Sunan Gunung Djati Bandung, Indonesia
(2) UIN Sunan Gunung Djati Bandung, Indonesia
(3) UIN Sunan Gunung Djati Bandung, Indonesia
(4) UIN Sunan Gunung Djati Bandung, Indonesia
(5) UIN Sunan Gunung Djati Bandung,  
(6) UIN Sunan Gunung Djati Bandung, Indonesia
(*) Corresponding Author

Abstract


Industrial development in Indonesia has caused increased pollution, including water pollution by heavy metals, one of which is the metal ion Cu(II). Cellulose acetate composite membranes have been widely used to overcome the problem of Cu(II) metal ion content in water, however, studies on the performance of cellulose acetate membranes with various types of chitosan, polyvinyl alcohol (PVA) and polyethylene glycol (PEG) composites have not been widely reported. This research aims to analyze the characteristics of cellulose acetate composite membranes with chitosan, PEG, and PVA using FTIR and SEM and to determine the performance of these cellulose acetate composite membranes in filtering Cu(II) metal from the resulting rejection values. The membrane was made using the phase inversion method and the composite membrane was made using the dip-coating method. The results of characterization using FTIR showed that there were no new peaks in all cellulose acetate composites, so there were only physical interactions in the composites. SEM analysis shows that the surface of the composite membrane is more irregular and the porosity increases. The performance of the composite membrane in filtering Cu(II) metal is better than the pure cellulose acetate membrane.


Keywords


cellulose acetate membrane; composite membrane; Cu (II) metal; filtration membrane; rejection value

Full Text:

PDF

References


P. Budiastuti, M. Rahadjo and N. A. Y. Dewanti, "Analisis pencemaran logam berat timbal di badan sungai babon kecamatan genuk semarang," Jurnal Kesehatan Masyarakat, 4(5). 119-122, 2016.

U. Khasanah, W. Mindari and P. Suryaminarsih, "Kajian pencemaran logam berat pada lahan sawah di kawasan industri kabupaten sidoarjo," Jurnal Teknik Kimia, 15(2),73-81, 2021.

https://doi.org/10.33005/jurnal_tekkim.v15i2.2545

J. Febrita and D. Roosmini, "Analisis beban pencemar logam berat industri terhadap," Jurnal Teknik Sipil Dan Lingkungan,7(1), 77-87, 2022.

https://doi.org/10.29244/jsil.7.1.77-88

Z. Fu and S. Xi, "The effects of heavy metals on human metabolism," Toxicology Mechanisms and Methods, 30(3), 167-176, 2020.

https://doi.org/10.1080/15376516.2019.1701594

A. Asati, M. Pichhode and K. Nikhil, "Effect of heavy metals on plants: an overview," International Journal of Application or Innovation in Engineering & Management (IJAIEM), 5(3), 56-66, 2016.

P. Govind and M. S, "Heavy metals causing toxicity in animals and fishes," Research Journal of Animal, Veterinary and Fishery Sciences, 2(2), 17-23, 2014. [6] P. Govind and M. S, "Heavy metals causing toxicity in animals and fishes," Research Journal of Animal, Veterinary and Fishery Sciences, 2(2), 17-23, 2014.

T. Aryani, "Sintesis Mg-Al-EDTA Hydrotalcite dan aplikasinya sebagai adsorben ion Cu2+," Tesis. Universitas Gajah Mada, Yogyakarta, 2014.

I. G. Wenten, Teknologi membran industrial, Bandung: Institut Teknologi Bandung, 2000.

S. Hube, M. Eskafi, K. F. Hrafnkelsdóttir, B. Bjarnadóttir, M. Á. Bjarnadóttir, S. Axelsdóttir and B. Wu, "Direct membrane filtration for wastewater treatment and resource recovery: A review," Science of The Total Environment, 710, 1-22, 2020.

https://doi.org/10.1016/j.scitotenv.2019.136375

A. Giwa, M. Ahmed and S. W. Hasan, "Polymers for membrane filtration in water purification. in: das, r. (eds) polymeric materials for clean water," in Springer Series on Polymer and Composite Materials, Springer, Cham, 2019.

https://doi.org/10.1007/978-3-030-00743-0_8

O. Kutowy and S. Sourirajan, "Cellulose acetate ultrafiltration membranes," J. Application Polymer Science, 19, 1449-1460, 1975.

https://doi.org/10.1002/app.1975.070190525

V. Vatanpour, M. E. P. Vatanpour, M. E. Pasaoglu, H. Barzegar, O. O. Teber, R. Kaya, M. Bastug, A. Khataee and I. Koyuncu, "Cellulose acetate in fabrication of polymeric membranes: A review," Chemosphere, 295, 2022.

https://doi.org/10.1016/j.chemosphere.2022.133914

M. A. A. El-Ghaffar, M. M. Elawady, A. M. Rabie and A. E. Abdelhamid, "Enhancing the RO performance of cellulose acetate membrane using chitosan nanoparticles," Journal of Polymer Research, 27, 337, 2020.

https://doi.org/10.1007/s10965-020-02319-7

J. Yin, H. Fan and J. Zhou, "Cellulose acetate/poly(vinyl alcohol) and cellulose acetate/crosslinked poly(vinyl alcohol) blend membranes: preparation, characterization, and antifouling properties," Desalination and Water Treatment, 57(23), 2016.

https://doi.org/10.1080/19443994.2015.1040846

A. Mansourizadeh and A. J. Azad, "Preparation of blend polyethersulfone/cellulose acetate/polyethylene glycol asymmetric membranes for oil–water separation," Journal of Polymer Research, 21, 375, 2014.

https://doi.org/10.1007/s10965-014-0375-x

M. K. M. Y. K. Kamal, E. M. Abdelrazek, N. M. Sellow and A. M. Abdelghany, "Synthesis adn optimization of Novel Chitosan/Cellulose Acetate Natural Polymer Membrane for Water Treatment," Journal of Advances in Physics, 14(1), 5303-5311, 2018.

https://doi.org/10.24297/jap.v14i1.7183

A. Ghaee, M. Shariaty-Niassar, J. Barzin, T. Matsuura and A. F. Ismail, "Preparation of chitosan/cellulose acetate composite nanofiltration membrane for wastewater treatment," Desalinaton and Water Treatment, 57(3), 1-8, 2015.

https://doi.org/10.1080/19443994.2015.1068228

D. Fransiska, S. Yuliati and R. Junaidi, "Membran Selulosa Asetat Berbasis Nata De Coco Ditinjau dari Pengaruh Penambahan Zat Aditif Polyethylene Glycol Terhadap Permeabilitas (Fluks)," Jurnal Serambi Engineering, 8(4), 7078-7085, 2023.

https://doi.org/10.32672/jse.v8i4.6739

A. Bernal-Ballén, I. Kuritka and P. Saha, "Preparation and Characterization of a Bioartificial Polymeric," International Journal of Polymer Science, 2016, 12 ,2016.

https://doi.org/10.1155/2016/3172545

Sabad-e-Gul, S. Waheed, A. Ahmad, S. M. Khan, M. Hussain, T. Jamil and M. Zuber, "Synthesis, characterization and permeation performance of cellulose acetate/polyethylene glycol-600 membranes loaded with silver particles for ultra low pressure reverse osmosis," Journal of the Taiwan Institute of Chemical Engineers, 57, 1-10, 2015.

https://doi.org/10.1016/j.jtice.2015.05.024




DOI: https://doi.org/10.15575/ak.v11i1.34722

Copyright (c) 2024 Vina Amalia, Tety Sudiarti, Rafa Mufidah, Yuliarti Yuliarti, Yusrina Nisrin, Yusuf Rohmatulloh

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

CrossrefSINTAGoogle ScholarIndonesia One Search

View My Stats

 

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.